+86 15516432285

ferro chrome slag crushed aggregates

USING OF FERRO-CHROME SLAG AS A COARSE AGGREGATE

Ferrochrome slag and fine aggregate by Stone Dust. Ferro-chrome slag is a waste material obtained from the production of Ferro-chrome, an essential component in stainless steel. It has been observed that Ferro-chrome slag waste is a suitable material for highway pavement work. This research work was conducted to know the performance of Ferro ...

More

ferro chrome slag crushed aggregates - lineco.co

ferro chrome slag crushed aggregates - hindusthanclub.co. crushed chromium oxide. transfer machine beds, welded iron, chromium . garnet sand, steel shots, crushed ...

More

USE OF FERROCHROME SLAG AS AGGREGATE IN CONCRETE-

Water absorption of ferrochrome slag aggregates as per IS 2386(III), 1997 is found to be 1.15% and 0.42% for water cooled ferrochrome slag and air cooled slag respectively. (C.R. Panda, K.K.Mishra, B. Nayak, 2014) 3. CHEMICAL PROPERTIES The chemical composition of ferrochrome slag aggregate is shown in Table 1.

More

IRJET- USING OF FERRO-CHROME SLAG AS A COARSE

As an artificial coarse aggregate in concrete which can substitute fully natural granite aggregates Chemical composition of Ferro-Chrome Slag.Ferrochromium is a master alloy of iron and chromium. In high carbon ferrochromium, metallic Cr content is 60-65% with varying amounts of Fe and C. Ferrochromium is produced pyrometallurgically by ...

More

ferro chrome slag crushed aggregates - smitarchitects.co

ferro chrome slag crushed aggregates . ferro chrome slag crushed aggregates from large primary jaws and gyratories to cones and VSIs for tertiary and quaternary ... aggregate washing machine in saudi arabia - allberta.co . crushed aggregates washing machine - SBM.

More

Studies on Use of Ferro Chrome Slag for Replacement of ...

Jun 15, 2019  This paper brings out the details of laboratory investigations carried out to find out suitability of ferro chrome slag as alternate road construction material. Bituminous samples using both ferrochromium slags and natural aggregates were prepared to determine their physical, mechanical, chemical properties through laboratory testing.

More

PRODUCTION, CHARACTERISTICS AND USE OF

the slag has to be higher than the metal smelting point, because metal is heated up by using slag liquid phase. The optimum smelting point has been practically noted between 1680-1720 °C. The composition of ferro-chrome slag in the phase diagram is shown in Figure 3. The proportion of quartzite in the charge mix controls the right slag ...

More

ferro chrome slag crushed aggregates

Ferro Chrome Slag Crushed Aggregates Grinding Stone 22mm . Ferro Chrome Slag Crushed Aggregates Grinding Stone 22mm 50mm. Grinding Media Grinding Balls Union Process Inc Diameter depending on the material ranging from 005 mm to 2 mm for small media mills up to 18” to 1” for traditional Attritors and up to ” to 2” for ball mills Composition metallic grinding media like carbon steel ...

More

(PDF) Utilization of ferrochrome wastes such as ...

The ferrochrome slag is having a porous and hard surface which can be crushed to make fine or coarse aggregates based upon the particle size of the slag. ... slag aggregate is used in this project ...

More

USING OF FERRO-CHROME SLAG AS A COARSE

Ferrochrome slag and fine aggregate by Stone Dust. Ferro-chrome slag is a waste material obtained from the production of Ferro-chrome, an essential component in stainless steel. It has been observed that Ferro-chrome slag waste is a suitable material for highway pavement work. This research work was conducted to know the performance of Ferro ...

More

USE OF FERROCHROME SLAG AS AGGREGATE IN CONCRETE

Water absorption of ferrochrome slag aggregates as per IS 2386(III), 1997 is found to be 1.15% and 0.42% for water cooled ferrochrome slag and air cooled slag respectively. (C.R. Panda, K.K.Mishra, B. Nayak, 2014) 3. CHEMICAL PROPERTIES The chemical composition of ferrochrome slag aggregate is shown in Table 1.

More

Durability Studies on Concrete with Ferro Chrome Slag as ...

Natural River sand and Ferro chrome slag was adopted as fine aggregate. The coarse aggregate used was crushed granite stone and gravel conforming to IS 383- 1970. Machine crushed hard granite chips of 67% passing through 20 mm sieve and retained on 12 mm sieve and

More

IRJET- USING OF FERRO-CHROME SLAG AS A COARSE AGGREGATE

As an artificial coarse aggregate in concrete which can substitute fully natural granite aggregates Chemical composition of Ferro-Chrome Slag.Ferrochromium is a master alloy of iron and chromium. In high carbon ferrochromium, metallic Cr content is 60-65% with varying amounts of Fe and C. Ferrochromium is produced pyrometallurgically by ...

More

Studies on Use of Ferro Chrome Slag for Replacement of ...

Jun 15, 2019  This paper brings out the details of laboratory investigations carried out to find out suitability of ferro chrome slag as alternate road construction material. Bituminous samples using both ferrochromium slags and natural aggregates were prepared to determine their physical, mechanical, chemical properties through laboratory testing.

More

ferro chrome slag crushed aggregates - smitarchitects.co

ferro chrome slag crushed aggregates . ferro chrome slag crushed aggregates from large primary jaws and gyratories to cones and VSIs for tertiary and quaternary ... aggregate washing machine in saudi arabia - allberta.co . crushed aggregates washing machine - SBM.

More

Use as aggregates

Ferrochrome slag BENEFICIAL USE/S Use as aggregates Concrete aggregates ... The product is crushed and screened to exact customer specifications. Alternatively, the ferrochrome is ... quality product, alloy recovery plants are utilised to recover the ferrochrome from the slag produced during the charge chrome process. The slag,

More

High Carbon Ferrochrome Technology - ScienceDirect

Jan 01, 2013  High carbon ferrochrome is an intermediate product and is used as a feed material in the production of value-added materials such as stainless steel. Typical product types for high carbon ferrochrome are crushed lumpy product with a silvery metallic appearance and irregular, flaky granulated product with a greenish appearance.

More

Chrome Ores on Ferrochrome Smelting

materials of chrome ores, fluxes, reductant and electrode paste. The Ferrochrome Simulation is developed using the principles of mass balance and heat balance, the interface can be seen in Fig. 2. The simulation requires three inputs and generates the results of charge recipe, mass and composition for slag

More

Ferro Chrome at Best Price in India

Ferro Chrome LC is available in Four different grades. Kanungo Steel Centre Grant Road, Mumbai 10, Shiv Kutir, Ground Floor, Shop No. 1, 8th Khetwadi Lane, Grant Road, Mumbai -

More

(PDF) Recovery of chromium from ferrochrome slag

Ferro chrome slag may contain chromium in +3 and +6 oxidation states. ... sections that gave the possibility to investigate steel slags in comparison to experienced natural aggregates like crushed ...

More

(PDF) POTENTIAL OF FERRO CHROME SLAG AS CONSTRUCTION MATERIAL

Potential of ferro chrome slag as construction material ... FeCr slag and SiFeCr slag have potential to be used as a pavement base layer material in applications where crushed limestone aggregate ...

More

Slag Metal Sorting : TOMRA

Sorting metal slag using sensor-based technology is one of the most efficient ways to recover valuable raw materials. Any melting process in industry produces metal and a by-product, called slag. Up to 15% of slag in the sortable size range consists of metals - either on the surface or encapsulated - which are valuable raw materials.

More

Slag-What is it Good for? - USGS

Ferrous slag is currently underutilized. Although the construction industry does use some slag as an aggregate, most is simply discarded. However, slag could be used to treat acid soils or acid mine drainage. Doing so would both offset the cost of restoring abandoned mine areas, as well as decrease steel manufacturers’ current waste footprint.

More

ferro chrome slag - Anyang Huatuo Metallurgy Co., LTD

ferro chrome slag. HOME > Blog. The micro-chromium iron slag is not a ferrochrome slag, but belongs to the category of ferrochrome slag. ... the filling action of the micro-chromium iron slag and the effect of the micro-aggregate make the micro-chromium iron slag be filled in the space of the cement particles, and the middle water is replaced ...

More

Use as aggregates

Ferrochrome slag BENEFICIAL USE/S Use as aggregates Concrete aggregates ... The product is crushed and screened to exact customer specifications. Alternatively, the ferrochrome is ... quality product, alloy recovery plants are utilised to recover the ferrochrome from the slag produced during the charge chrome process. The slag,

More

(PDF) POTENTIAL OF FERRO CHROME SLAG AS CONSTRUCTION MATERIAL

Potential of ferro chrome slag as construction material ... FeCr slag and SiFeCr slag have potential to be used as a pavement base layer material in applications where crushed limestone aggregate ...

More

(PDF) Recovery of chromium from ferrochrome slag

Ferro chrome slag may contain chromium in +3 and +6 oxidation states. ... sections that gave the possibility to investigate steel slags in comparison to experienced natural aggregates like crushed ...

More

environmental affairs - Department of Environment ...

Ferrochrome slag Use as aggregates Concrete aggregates ... The product is crushed and screened to exact customer specifications. Alternatively, the ferrochrome is ... utilised to recover the ferrochrome from the slag produced during the charge chrome process. The slag, which has a metallic content of approximately 4 percent, ...

More

Hexavalent chromium removal by ferrochromium slag ...

Nov 11, 2005  1. Introduction. Ferrochromium is a master alloy of iron and chromium, containing 45–80% Cr and various amounts of Fe, C and other elements. Ferrochromium is produced pyrometallurgically by carbothermic reduction of chromite ore (FeOCr 2 O 3).The main slag additives used are quartzite and aluminium oxide containing materials to compensate for the high magnesium

More

CHARACTERIZATION OF FERROCHROME SLAG AS AN

The specific gravity experiment is done in pycnometer method as per IS 2720 Part III Sec 2 1980 for fine grain ferrochrome slag, red mud, fly ash, red soil, red soil with different proportion (i.e. 10%, 20%, 30%, 40%, 50%) of ferrochrome slag and IS 2386(Part III) – 1963 for coarse grain ferrochrome slag.

More

Chrome Ores on Ferrochrome Smelting

materials of chrome ores, fluxes, reductant and electrode paste. The Ferrochrome Simulation is developed using the principles of mass balance and heat balance, the interface can be seen in Fig. 2. The simulation requires three inputs and generates the results of charge recipe, mass and composition for slag

More

Metal Recovery and Crushing Plants Harsco Environmental

Crushing and sizing the demetallized slag generates specific size fractions for marketing as aggregates, too – and Harsco Environmental has a long history of innovating within the MRP refining process and component design space. Our in-house software, BloodHound™, is a unique system that detects Fe (iron) in demetallized slag.

More

Slag Metal Sorting : TOMRA

Sorting metal slag using sensor-based technology is one of the most efficient ways to recover valuable raw materials. Any melting process in industry produces metal and a by-product, called slag. Up to 15% of slag in the sortable size range consists of metals - either on the surface or encapsulated - which are valuable raw materials.

More

Balasore Alloys : Metal Recovery Facilities

This crushed material then passes through the jigging plant where the chrome and slag are separated by means of gravity. The slag chips known as tailings are sold away for pit filling or road building or even for construction purpose. This facility is a major initiative taken by the company towards waste recovery and environmental protection.

More

CHROMIUM ALLOYS PRODUCTION AND OPERATION A

liquid slag composition selected, is about 1600 to 1650 °C for free flow of metal from the furnace. The main components of slag are Si02, MgO, Alz03, CaO and Oxides ofCr and Fe. Typical composition of Ferro Chrome Slag is shown below in table 1. Table 1: Typical composition of Ferro Chrome Slag Fe0% 14 -16 2-4 26-30

More

Slag-What is it Good for? - USGS

Ferrous slag is currently underutilized. Although the construction industry does use some slag as an aggregate, most is simply discarded. However, slag could be used to treat acid soils or acid mine drainage. Doing so would both offset the cost of restoring abandoned mine areas, as well as decrease steel manufacturers’ current waste footprint.

More

Crusher Suitable For Ferrochrome Slag

crusher suitable for ferrochrome slag « gravel crusher sale. crusher suitable for ferrochrome slag Description : modern practices of post taphole operation in ferro chrome of Ferro Chrome, resulting in higher recovery of chromium. Read more

More