+86 15516432285

cumene production ppt

Cumene Production Slide Show (group 7)

2015-7-14  Cumene Production Slide Show (group 7) 1. DESIGN OF A PLANT TO PRODUCE 10,000 TONS PER DAY OF CUMENE FROM THE REACTION OF PROPYLENE AND BENZENE IN THE PRESENCE OF AN ACID CATALYST An Undergraduate Design Report Presented By GROUP SEVEN TO THE DEPARTMENT OF CHEMICAL ENGINEERING, FEDERAL UNIVERSITY OF

More

PPT - PRESENTATION ON CUMENE PLANT

2012-9-2  PRESENTATION ON CUMENE PLANT. 15 TH FEB 2012. PRESENTED BY HARIDASAN V A. CAPACITY AND TECHNOLOGY. Plant capacity : 290,000 MT of Cumene per year On stream factor : 8,000 Hours Hourly production rate : 36.25 MT/hr

More

PPT – Catalytic Production of Cumene PowerPoint ...

Title: Catalytic Production of Cumene 1 Catalytic Production of Cumene. Consider our phenol acetone process, illustrated below. 2 Catalytic Production of Cumene. Is this a gas-phase, condensed-phase, or multi-phase reaction? What is the mechanism for acid-catalyzed alkylation of benzene with propylene? What reasonable rate expression can be derived

More

Process Design And ANALYSIS of cumene production

2019-4-12  Monsanto – Lummus Crest Cumene Process. 2. Q-Max cumene production process is the method adopted for our design. • The commercial production of cumene is by Friedel-Crafts alkylation of benzene with propylene. • The Q-Max process converts a mixture of benzene and propylene to high quality cumene using a regenerable zeolite catalyst.

More

Material Balances Design Problem Cumene Production

2016-8-1  Cumene Production Reactions The reactions for cumene production from benzene and propylene are as follows: C 3H 6 + C 6H 6 → C 6H 5-C 3H 7 propylene benzene cumene C 3H 6 + C 6H 5-C 3H 7 → C 3H 7-C 6H 4-C 3H 7 propylene cumene diisopropyl benzene (DIPB) The best technology for cumene production is a catalytic process that is optimized at ...

More

Reactors and Separations Design Project Production of

2016-8-1  The above equation for estimating the cost of cumene is based on the minimum price that cumene could be sold for to cover our operating expenses. These economic details were introduced in ChE 38, and will be covered in more detail in ChE 182/183. You should use a 10-year plant lifetime and an interest rate of 15%. Cumene Production Reaction

More

PRODUCTION OF PHENOL AND ACETONE FROM

PRODUCTION OF PHENOL AND ACETONE FROM CUMENE: DETAILED DESIGN OF THE CLEAVAGE UNIT Detailed Design of Reactors Detailed Design of Reactors Determination of the mass flow of cooling water Agitator for CSTR Pitch Bladed

More

Acetone - SlideShare

2015-5-3  1) CUMENE PROCESS • The air oxidation of cumene (isopropyl benzene) leads to the production of both phenol and acetone, as shown in the following figure. The mechanisms for the formation and degradation of cumene hydroperoxide require closer looks, which are provided following the figure. 11. REACTIONS 12. REACTIONS 13.

More

Présentation PowerPoint - cdn-cms.f-static

2016-12-9  Production de TiO2 : limitation sévère des rejets liés au procédé d ’extraction du minerai par H2SO4 -> développement de la technique au chlore 3. Oxydation de SO2 en SO3 : SO2 + 1/2 O2 -> SO3 Dn P -> réaction favorisée pourtant procédé de double catalyse (P faible) Accueil Evolution des méthodes d’obtention • Exemple ...

More

PPT – Catalytic Production of Cumene PowerPoint ...

Title: Catalytic Production of Cumene 1 Catalytic Production of Cumene. Consider our phenol acetone process, illustrated below. 2 Catalytic Production of Cumene. Is this a gas-phase, condensed-phase, or multi-phase reaction? What is the mechanism for acid-catalyzed alkylation of benzene with propylene? What reasonable rate expression can be derived

More

Process Design And ANALYSIS of cumene production

2019-4-12  Monsanto – Lummus Crest Cumene Process. 2. Q-Max cumene production process is the method adopted for our design. • The commercial production of cumene is by Friedel-Crafts alkylation of benzene with propylene. • The Q-Max process converts a mixture of benzene and propylene to high quality cumene using a regenerable zeolite catalyst.

More

PRODUCTION OF PHENOL AND ACETONE FROM

PRODUCTION OF PHENOL AND ACETONE FROM CUMENE: DETAILED DESIGN OF THE CLEAVAGE UNIT Detailed Design of Reactors Detailed Design of Reactors Determination of the mass flow of cooling water Agitator for CSTR Pitch Bladed Turbine Ideal for bulk fluid mixing Detailed Design of

More

Cumene Production Plant Distillation Catalysis ...

2020-4-20  Cumene Production Plant - Free download as Powerpoint Presentation (.ppt / .pptx), PDF File (.pdf), Text File (.txt) or view presentation slides online. A powerpoint presentation outlining economic and design factors for an isopropylbenzene plant. Provides economic considerations to include global market analysis All units (distillation columns, reactors..ect) are designed.

More

PERP Program – Phenol/Acetone/Cumene New Report Alert

2019-12-16  Q107_00101.0006.4111.PPT The majority of acetone is produced as a co-product of phenol production from cumene. Small volumes are produced from mola sses fermentation and acetic acid production. The only on-purpose acetone production is from dehydrogenation of isopropyl alcohol. Acetone has numerous uses:

More

Aromatics Product Profile, Ethylbenzene Styrene,

Production of phthalic anhydride from o-xylene is similar to naphthalene route. Catalytic oxidation of o-xylene is done either in fixed bed catalytic reactor having multi tube or fluidised bed reactor in the presence of vanadium pentoxide and titanium oxide catalyst. Cumene . Cumene is made by alkylkating benzene with propylene using zeolite ...

More

(PDF) Acetone Production - ResearchGate

Cumene process: Analysis of sulfuric acid in acetone and phenol. Mills, B. (2009). ... However, numerous factories have struggled with production costs and a lack of government funding due to ...

More

新版换热网络实例教程 V9以上版本.pdf - max文档投稿赚钱

2019-7-1  Commercial production of cumene happens through the Friedel–Crafts alkylation of benzene with propylene. As shown in Figure 1, fresh benzene (C6) mixed with recycle benzene and fresh propylene (95% propylene and 5% propane) are preheated and vaporized using the hot reactor effluent in a feed- effluent heat exchanger before being heated to the reaction temperature in a furnace.

More

PROII培训讲义之软件入门_百度文库

2007-8-26  Example1: Cumene Production Flowsheet .....11 Example 2: Benzene Flowsheet Simulation.....28 精馏塔的初步设计和详细 ... Wed Jul 17 17:08:35 2002 TITLE SEQUENCE SIMSCI COMPONENT DATA LIBID 1,BENZENE/2,PROPENE/3,CUMENE ...

More

(PDF) CHE231 - Final Year Report Plant Design:

The production of styrene using many equipment such as reactor (with floating head shell and tube), reactor feed heating system (3 unit), reactor effluent cooling system (2 unit), 3-phases separator, pre-separating effluent heat exchanger, column 1, column 2, column 3

More

Process Design And ANALYSIS of cumene production

2019-4-12  Monsanto – Lummus Crest Cumene Process. 2. Q-Max cumene production process is the method adopted for our design. • The commercial production of cumene is by Friedel-Crafts alkylation of benzene with propylene. • The Q-Max process converts a mixture of benzene and propylene to high quality cumene using a regenerable zeolite catalyst.

More

plant layout for acetone production plant

Cumene Production Plant - Free download as Powerpoint Presentation (.ppt / .pptx), PDF File (.pdf), Text File (.txt) or view presentation slides online. A powerpoint presentation outlining economic and design factors for an isopropylbenzene plant. Provides economic considerations to include global market analysis All units (distillation columns ...

More

Q Max Cumene Production Benzene Chemical Reactor

2015-4-20  The Q-Max process represents a new generation of cumene technology based upon a highly selective, robust and stable zeolitic catalyst. The Q-Max process provides excellent cumene product quality (99.97 wt-% purity) and near-stoichiometric cumene yield (>99.7 wt-%). The QZ-2000 zeolitic catalyst used in the Q-Max process operates with low benzene circulation, resulting in low investment

More

(PDF) Production of phenol from cumene - Systematic

A production rate of 300,000 metric tons/year of phenol is considered. In the base case, 0.66 kg of phenol and 0.41 kg of acetone are produced per kg of cumene with an energy consumption of 23,181 ...

More

Aromatics Product Profile, Ethylbenzene Styrene,

Production of phthalic anhydride from o-xylene is similar to naphthalene route. Catalytic oxidation of o-xylene is done either in fixed bed catalytic reactor having multi tube or fluidised bed reactor in the presence of vanadium pentoxide and titanium oxide catalyst. Cumene . Cumene is made by alkylkating benzene with propylene using zeolite ...

More

CatalyCatalytic Distillationtic Distillation

2010-5-25  Example: Cumene Production Shoemaker, J.D., Jones, E.M., Hydrocarbon Processing (1987) 57-58. Reaction Scheme lp = 3 - 10 bar, T max ≈ 250 °C lSolid acid catalyst lReaction heat: (-∆ RH) ≈ 113 kJ/mol lBy-product formation favoredat higher T Benzene Cumene Propylene + +

More

Integrated cumene- phenol/acetone/Bisphen ol A- Part I:

2020-5-4  All commercial production of cumene proceeds via alkylation of benzene with propylene at elevated temperature and pressure in the presence of an acid catalyst. While cumene manufacture was dominated by processes using solid phosphoric acid (SPA) catalyst systems for decades, the industry landscape changed dramatically beginning in the mid-1990s ...

More

Propylene Derivatives Products Of Chemical Industry ...

2021-2-3  Approximately 83% of acetone is produced via the cumene process, as a result, acetone production is tied to phenol production. In the cumene process, benzene is alkylated with propylene to produce cumene, which is oxidized by air to produce phenol and acetone: Other processes involve the direct oxidation of propylene (Wacker-Hoechst process ...

More

Refining 101 - API

2012-5-9  Production Supply REFINING Distribution Marketing . 6 Crude Oil Products Other Feedstocks Petroleum Refinery Safely, and efficiently transform crude oil and other raw ... Cumene 2902 . Refining Resources Marathon Petroleum “The Basics of Refining”

More

(PDF) CHE231 - Final Year Report Plant Design:

The production of styrene using many equipment such as reactor (with floating head shell and tube), reactor feed heating system (3 unit), reactor effluent cooling system (2 unit), 3-phases separator, pre-separating effluent heat exchanger, column 1, column 2, column 3

More